Product ID:ADDITIVE, LACQUER 10 FEE
MSDS Date:02/01/1989
FSC:8010
NIIN:01-046-5006
MSDS Number: BHNBX

E.I. DU PONT DE NEMOURS & CO. (INC.)

AUTOMOTIVE PRODUCTS DEPARTMENT
WILMINGTON, DE 19898
US

Emergency Phone: 800-441-3637 OR 800-424-9300

Info Phone: 800-441-7515

Cage: 18773

E.I. DU PONT DE NEMOURS & CO., INC.

WILMINGTON, DE 19898 US

Telephone: 800-441-7515

Cage: 18773

N-BUTYL ACETATE (SARA III)

CAS: 123-86-4

RTECS: AF7350000

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM/200STEL;9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

N-BUTYL ACETATE (SARA III)

CAS: 123-86-4

RTECS: AF7350000

OSHA PEL 150 PPM/200 STEL

ACGIH TLV: 150 PPM/200STEL;9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOBUTYL ACETATE (SARA III)

CAS: 110-19-0

RTECS: AI4025000

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

VOC. ORGANIC CMPD 3.2-8.3 LB/GAL

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:INGESTION: GASTRO-INTESTINAL DISTRESS.
INHALE: PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. INGRED MAY BE USED
W/ISOCYANATE, MAY CAUSE ASTHMA-LIKE REACTIONS W/SHORTNESS OF
BREATH. SKIN OR EYE CONTACT: IRR ITATION OR BURNING OF THE EYES
ALSO SKINIRRITATION WITH DISCOMFORT AND DERMATITIS
Explanation of Carcinogenicity:PRODUCT CONTAINS CHEMICALS KNOWN TO THE
STATE OF CA TO CAUSECANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
Effects of Overexposure:INGESTION: GASTRO-INTESTINAL DISTRESS. INHALE:
NOSE & THROAT IRRITATION. EYE WATERING, HEADACHES, NAUSEA,
DIZZINESS & LOSS OF COORDINATION ARE SIGNS SOLVENT LEVELS ARE TOO
HIGH. EXPOSURE TO ISOCYANATE S; SHORTNESS OF BREATH, WHEEZING,
COUGHOR LUNG SENSITIZATIONS. SKIN: DISCOMFORT OR DERMATITIS. EYE:
BURNING, IRRITATION
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH LUNG OR BREATHING
PROBLEMS OR PRIOR REACTION TO ISOCYANATES MUST NOT BE EXPOSED TO
VAPORS OR SPRAY MIST OF THIS PRODUCT

First Aid:IN UNLIKELY EVENT OF INGESTION: CALL PHYSICIAN IMMED, HAVE
NAMES OF INGREDIENTS AVAILABLE. INHALE: REMOVE TO FRESH AIR. IF
BREATHING DIFFICULTY PERSISTS, OR OCCURS LATER, CONSULT PHYSICIAN.
EYE CONTAC T: IMMEDIATELY FLUSH WITH PLENTY WATERFOR 15 MINUTES;
CALL PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. IF IRRITATION
OCCURS, CONTACT PHYSICIAN.

Flash Point Method:CC
Flash Point:73 F/ 22.78 C
Lower Limits:0.9
Upper Limits:13.1
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT. SELF-CONTAINED
BREATHING APPARATUS RECOMMENDED. WATERFROM FOG NOZZLES MAY BE USED
TO COOL CLOSED CONTAINERS, PREVENT PRESSURE BUILDUP
Unusual Fire/Explosion Hazard:HEATED ABOVE THE FLASH POINT, EMITS FLAM
VAPORS WHICH, MIXED WITH AIR, CAN BURN/EXPLOSIVE. FINE MISTS/SPRAY
MAY BE FLAMMABLE AT TEMPERATURE BELOW FLASH POINT

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PRE- VENT SKIN CONTACT AND BREATHING OF VAPORS. WEAR A PROPERLY
FITTED VAPOR/PARTICULATE RESPIRATOR (NIOSH/MSHA TC-23C). CONFINE
AND REMOVE WITH INERT ABSO BANT.

Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS & FLAME. CLOSE CONTAINER AFTER EACH USE.
GROUND CONTAINERS WHEN POURING. WASH THOROUGHLY.
Other Precautions:DO NOT STORE ABOVE 120 F. WASH THOROUGHLY AFTER
HANDLING AND BEFORE EATING OR SMOKING.

Respiratory Protection:DO NOT PERMIT ANYONE WITHOUT RESPIRATORY
PROTECTION IN PAINT AREA. IF ISOCYANATEARE USED OR CONFINED AREA
WEAR A POSITIVE PRESSURE, SUPPLIED AIR RESPIRATOR (NIOSH/MSHA
TC-19C APPROVED) WITHOUT ISOCYAN ATE, APPROVED PAINT SPRAY
RESPIRATOR
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOL/PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES
Eye Protection:DESIRABLE, SPLASH GUARDS OR SIDE SHIELDS
Other Protective Equipment:NEOPRENE GLOVES AND COVERALLS ARE
RECOMMENDED
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR SMOKING
Supplemental Safety and Health
NOTICE: THE DATA IN THIS MATERIAL SAFETY DATA SHEET RELATE ONLY TO THE
SPECIFIC MATERIAL DESIGNATED HEREIN AND DO NOT RELATE TO USE IN
COMBINATION WITH ANY OTHER MATERIAL OR IN ANY PROCESS.

HCC:F3
Boiling Pt:B.P. Text:76-190 C
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NK ***(PERCENT VOLATILES BY VOLUME: 53.2-99.7%)
Percent Volatiles by Volume:***

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE
Hazardous Decomposition Products:CO, CO2, SMOKE
Conditions to Avoid Polymerization:WILL NOT OCCUR

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORD- ANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS. DONOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.